Product ID:MIL-L-19537C AM3 (16473 GRAY)
MSDS Date:09/01/1988
FSC:8010
NIIN:00-527-2478
MSDS Number: BTZZX

KOPPERS CO INC

3000 KOPPERS BLDG
PITTSBURGH, PA 15219-1818
US

Emergency Phone: 800-553-5631, CHEMTREC 800-424-9300

Info Phone: 800-553-5631

Cage: 80592

KOPPERS CO INC

PITTSBURGH, PA 15219-1818 US

Cage: 80592

TOLUENE (SARA III)

CAS: 108-88-3

RTECS: XS5250000

Fraction By Weight: 5-10%

OSHA PEL 200 PPM/150 STEL

ACGIH TLV: 50 PPM; 9293

EPA Report Quantity: 1000 LBS

DOT Report Quantity: 1000 LBS

TITANIUM DIOXIDE

CAS: 13463-67-7

RTECS: XR2275000

Fraction By Weight: 10-15%

OSHA PEL 15 MG/M3 TDUST

ACGIH TLV: 10 MG/M3 TDUST; 9293

DI-SEC-OCTYL PHTHALATE (DI-2-ETHYLHEXYLPHTHALATE) (SARA

CAS: 117-81-7

RTECS: TI0350000

Fraction By Weight: 5-10%

OSHA PEL 5 MG/M3

ACGIH TLV: 5 MG/M3; 9394

EPA Report Quantity: 100 LBS

DOT Report Quantity: 100 LBS

N-BUTYL ACETATE (SARA III)

CAS: 123-86-4

RTECS: AF7350000

Fraction By Weight: 15-20%

OSHA PEL 150 PPM/200 STEL

ACGIH TLV: 150 PPM/200STEL;9192

EPA Report Quantity: 5000 LBS

DOT Report Quantity: 5000 LBS

METHYL ETHYL KETONE (2-BUTANONE) (MEK) (SARA III)

CAS: 78-93-3

RTECS: EL6475000

Fraction By Weight: 30-35%

OSHA PEL 200 PPM/300 STEL

ACGIH TLV: 200 PPM/300STEL 9192

EPA Report Quantity: 5000 LBS

DOT Report Quantity: 5000 LBS

ISOPROPYL ALCOHOL (SARA III)

CAS: 67-63-0

RTECS: NT8050000

Fraction By Weight: 1-5%

OSHA PEL 400 PPM/500 STEL

ACGIH TLV: 400 PPM/500STEL;9192

Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:YES IARC:NO OSHA:NO
Health Hazards Acute and Chronic:EYE:IRRITATION. SKIN: DEFATTING,
IRRITATION. INHALATION:MAY CAUSE RESPIRATORY TRACT IRRITATION AND
CNS DEPRESSION. INGESTION:IRRITATION OF GI TRACT, ASPIRATION INTO
LUNGS MAY CAUSE CHEMICAL PNEUMONITI S. CHRONIC-DERMATITIS, LIVER,
KIDNEY & CNS DAMAGE. TARGET ORGANS:SKIN, LUNGS, LIVER AND KIDNEY.
Explanation of Carcinogenicity:NTP HAS DETERMINED THAT THERE IS
SUFFICIENT EVIDENCE FOR CARCINOGENICITY OF DIOCTYL PHTHALATE IN
EXPERIMENTAL ANIMALS.
Effects of Overexposure:INHALATION-HEADACHE, WEAKNESS, DIZZINESS,
INCOORDINATION & POSSIBLE COLLAPSE. INGESTION:NAUSEA, VOMITING,
DIARRHEA & EFFECTS SIMILAR TO THOSE DESCRIBED UNDER INHALATION.
Medical Cond Aggravated by Exposure:PRE-EXISTING DISEASE IN OR A
HISTORY OF AILMENTS INVOLVING SKIN, EYE, RESPIRATORY TRACT, LIVER,
KIDNEY, CENTRAL NERVOUS SYSTEM ARE A GREATER THAN NORMAL RISK OF
DEVELOPING ADVERSE EFFECTS W/EXPOSURE.

First Aid:INHALATION:REMOVE TO FRESH AIR, PROVIDE CPR/OXYGEN IF NEEDED.
EYE CONTACT:FLUSH WITH WATER FOR 15 MINUTES. GET MEDICAL HELP. SKIN
CONTACT:WASH WITH SOAP AND WATER. REMOVE CONTAMINATED CLOTHING. GET
ME D ATTENTION IF SYMPTOMS PERSIST. INGESTION:DO NOT INDUCE
VOMITING, DRINK 1-2 GLASSES OF WATER OR MILK. GET MEDICAL HELP
IMMEDIATELY.

Flash Point Method:CC
Flash Point:24.0F,-4.4C
Autoignition Temp:Autoignition Temp Text:NIF
Extinguishing Media:USE CO2, DRY CHEMICAL, WATER SPRAY, ALCOHOL OR
UNIVERSAL TYPE FOAM PER MFR'S RECOMMENDATIONS. WATER MAY BE
INEFFECTIVE.
Fire Fighting Procedures:WEAR COMPLETE FIRE SERVICE PROTECTIVE EQUIP,
INCLUDING FULL-FACE MSHA/NIOSH APPROVED SCBA. USE WATER TO COOL
FIRE- EXPOSED CONTAINER/STRUCTURE/PROTECT PERSONNEL
Unusual Fire/Explosion Hazard:VAPORS FORM FLAM/EXPLOSIVE MIXTURE IN
AIR. VAPORS MAY TRAVEL TO IGNITION SOURCE & FLASH BACK. CLOSED
CONTAINER MAY EXPLODE W/HEAT. MAY EMIT IRRIT/TOXIC GAS/FUME

Spill Release Procedures:STOP SPILL/LEAK IF NO RISK INVOLVED. WEAR
PROTECTIVE EQUIPMENT. AVOID BREATHING VAPORS. REMOVE IGNITION
SOURCES. VENT AREA. AVOID CONTACT W/HOT LIQUID & FUMES. AVOID
HEAT/SPARKS. USE INERT ABSORBENTS TO COMPLETE CLEAN-UP.

Handling and Storage Precautions:AVOID CONTACT W/SKIN OR EYES &
BREATHING OF VAPORS/MISTS. HANDLE, USE, SPRAY PAINT PER 29 CFR
1910.107.
Other Precautions:STORAGE PER OSHA 1910.106. KEEP IN CLOSED, LABELED
CONTAINER IN A COOL, DRY, WELL-VENT AREA. KEEP FROM IGNITION
SOURCES. PROTECT FROM PHYSICAL DAMAGE. DO NOT USE PRESSURE TO EMPTY
DRUMS. DO NOT WEAR C ONTAM CLOTHING. DISCARD CONTAM FOOTWEAR.

Respiratory Protection:IF VENT DOES NOT MAINTAIN INHAL EXPOS BELOW
PEL(TLV), USE MSHA/NIOSH APPR'D UNITS AS PER 29 CFR 1910.134,
INSTRUCTIONS/ WARNINGS & NIOSH-RESPIRATOR DECISION
LOGIC-PUB.#87.108. IF WITHIN, OSHA PROTECT FACTOR, AIR PURIFYING
OV/FILTER UNIT OK
Ventilation:SUFFICIENT GENERAL/LOCAL EXHAUST VENTILATION TO CONTROL
INHALATION EXPOSURE. LOCAL EXHAUST IN CONFINED/ENCLOSED SPACES.
Protective Gloves:HEAVY DUTY NEOPRENE OR EQUAL.
Eye Protection:SAFETY GLASSES, SIDE SHIELDS, GOGGLES.
Other Protective Equipment:WEAR INDUST-TYPE WORK CLOTH & SAFETY SHOES.
Work Hygienic Practices:OBSERVE GOOD PERSONAL HYGIENE PRACTICES.
MAINTAIN GOOD HOUSEKEEPING. THOROUGHLY WASH BEFORE EATING,
DRINKING, SMOKING.
Supplemental Safety and Health
IF THIS PRODUCT IS RELEASED INTO THE ENVIRONMENT MUST BE REPORTED TO
THE NAT'L RESPONSE CENTER (1-800-424-8802). THE REPORTABLE QUANTITY
IS 100 LBS. OR MORE. DO NOT WEAR CONTACT LENS WITHOUT PROPER EY E
PROTECTION WHEN USING THIS PRODUCT.

HCC:F2
Vapor Density:>1
Viscosity:NIF
Solubility in Water:NEGLIGIBLE
Appearance and Odor:GRAY VISCOUS LIQUID WITH A TYPICAL SOLVENT ODOR.

Stability Indicator/Materials to Avoid:YES
OXIDIZING AGENTS, HEAT, SPARKS AND OPEN FLAMES.
Stability Condition to Avoid:NONE
Hazardous Decomposition Products:CARBON MONOXIDE, CARBON DIOXIDE UPON
THERMAL DECOMPOSITION.

Waste Disposal Methods:THIS PRODUCT IS A US EPA DEFINED IGNITABLE
HAZARDOUS WASTE. DISPOSE OF AS AN IGNITABLE HAZARDOUS WASTE IN
ACCORDANCE WITH LOCAL, STATE AND FEDERAL REGULATIONS.

Disclaimer (provided with this information by the compiling agencies):
This information is formulated for use by elements of the Department
of Defense. The United States of America in no manner whatsoever,
expressly or implied, warrants this information to be accurate and
disclaims all liability for its use. Any person utilizing this
document should seek competent professional advice to verify and
assume responsibility for the suitability of this information to their
particular situation.